Factory Service Manual For Tigercat Mulcher. Manual Contains Illustrations, Instructions, Diagrams For Step By Step Remove And Install, Assembly And Disassembly, Service, Inspection, Repair, Troubleshooting, Tune-Ups.

Format: PDF
Language: English
Quantity of Manuals: 2
Pages: 213; 222
Number: 14674A (october 2006); 30681A (february 2008P
Bookmarks
Searchable
Wiring Diagrams
Hydraulic Diagrams

Model

Tigercat Mulcher
M760

Contents

INTRODUCTION
S.A.E. STANDARDS
NON-APPROVED FIELD PRODUCT CHANGES
-SAFETY
Articulation Lock Bar
Battery Disconnect Switch
Boom Lift Lock
Cab Exits
Emergency Cab Exits
Engine Access Panels
Fire Prevention
Fluid Injection Injury
Grease Injection Injury
Hazard Zone
Mulching Operation Safety
Parking The Machine
Safety Interlock Switches On Cab Doors
Safety Precautions, General
Safety Precautions, Operating
Safety Precautions, Servicing
Safety Symbols
Signal Words
-USING HIGH SPEED DISC SAWS SAFELY
Comments And Instructions
Dangers
Forward
High Angle Wrist Rotation Capability
Saw Head Don’ts
Type Of Housing Makes A Difference
-LUBRICATION & MAINTENANCE
Air Conditioning System, Checking
Approved Hydraulic Oils
Belt, Engine Serpentine, Replacing
Blink Codes
Center Joint
Drive Shaft Spline Lubrication, Middle And Rear
Electrical Schematic
Electronic Controller Blink Codes
Emergency Exits, Check Monthly
Engine Maintenance Chart
Engine Serpentine Belt, Replacing
Filters
Fire Prevention
Hydraulic Oils, Approved
Lubrication And Service Points Chart
Machine Start-Up
New Machine Maintenance
Oil Lost From Leakage
Oil Sample Collection Procedures
Oil Sampling Program
Pressure/Speed Settings
Pressurized Water System
Replacing Engine Serpentine Belt
Scheduled Maintenance
Speed Control Lever Adjustment
Start-Up
Startup Procedure
Torque Chart
Torque, Fluid Connections
Torque Specifications – General
Transmission
Wheels, Installing
-PILOT SYSTEM
Accumulator Charge Valve
Accumulators
Components
Hydraulic Oil Heating Procedure
Pilot Circuit Description
Pilot Circuit Schematic
Pilot Manifold
Pilot Pressure Settings
Release Pilot System Pressure
-ELECTRICAL, GAUGES & ALARMS
A/C Heater Relays
Battery Compartment
Battery Disconnect Switch
Blink Codes
Charging System
Controls And Instruments
Display Module
Electrical Component Locations
Electrical Connections
Electrical Schematic
Electrical System Description
Electronic Controller Blink Codes
Fuse And Relay Compartment
Instrument Panel
Sensor, Sender Locations
Wire Colour Code Chart
-ENGINE
Cooling System
Engine Rpm
Engine, Starting
Engine, Stopping
Precleaner
Start Circuit Diagrams
Starting Engine
Starting System Description
Stopping Engine
-DRIVE
Axles
Circuit Description
Circuit Diagram, Drive
Drive Pedal Pilot Valve
Drive Prevent Valve
Drive Pump And Motor Pressure Settings And Adjust
Drive Shaft, Front, Installation
Hydrostatic Drive Motor
Hydrostatic Drive System
Speed Control Lever Valve
Test Drive
Transmission 1-Speed (Dual Motor)
Wheel Installation
-BRAKES AND DIFFERENTIAL LOCKS
Auxiliary Set-Up Caliper
Brakes
Differential Locks
Parking Brake
-OIL COOLER/RADIATOR/CROSS-FLOW FAN
Charge Air Cooler
Cooling System
Cooling System, Engine. See Section 7 In This Manual
Engine Access Panels
Engine Cooling System. See Section 7 In This Manual
Fan Cooling Circuit Description
Fan Speed Checks
Hydraulic Hand Fill Pump
Oil Cooler
Oil Cooler And Radiator Installation
Oil Cooler Circuit Description
-STEERING AND CENTER JOINT
Center Joint
Circuit Description
Circuit Diagram
Joystick
Pressure Settings
Pressure Settings
Priority Valve
Pump
Relief Valve
Steering Joystick
Steering Wheel
Steering Wheel
Testing The Steering Operation
-LIFT BOOM
Boom Lift Lock
Boom Valve
Circuit Description
Circuit Diagram
Joystick Control Valve
Pressure Settings
Pump, Description
Relief Valves
-TILT
Boom Lift Lock
Boom Valve Diagram
Circuit Description
Circuit Diagram
Control Valves
Pressure Settings
Relief Valves
-ATTACHMENT DRIVE
Accumulator
Attachment Motor. See Attachment Manufacturer’s Manual
Attachment Pump
Circuit Description
Pressure Settings
Safety
-MULCH DEFLECTOR DOOR
Boom Lift Lock
Boom Valve
Circuit Description
Circuit Diagram
Control Valves
Pilot Line Pressures See Section 5 – Pilot System
Pressure Settings
Relief Valves
Safety
Spool Section Diagram